Product ID:SPIRAX HEAVY DUTY 80 W/90,59210
MSDS Date:06/13/1989
FSC:9150
NIIN:01-035-5392
MSDS Number: CFKSB

SHELL OIL COMPANY

HEALTH, SAFETY AND ENVIRONMENT
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461/800-424-9300(CHEMTREC)

Info Phone: 713-241-4819/4141/2252 FAX -6511

Cage: 54527

SHELL OIL COMPANY

UNKNOW HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

SOLVENT REFINED HYDROTREATED RESIDUAL OIL

CAS: 64742-57-0

Fraction By Weight: 30 - 70%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

SOLVENT REFINED HYDROTREATED HEAVY PARAFFINIC

CAS: 64742-54-7

RTECS: PY8035500

Fraction By Weight: 9 - 40%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

SEVERELY HYDROTREATED HEAVY NAPHTHENIC DISTILLATE/MINERAL

CAS: 64742-52-5

RTECS: PY8035000

Fraction By Weight: 15 - 40%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

SEVERELY HYDROTREATED LIGHT NAPHTHENIC DISTILLATE/MINERAL

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 10 - 30%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

HYDROTREATED MIDDLE PETROLEUM DISTILLATE

CAS: 64742-46-7

RTECS: JN9379645

Fraction By Weight: <10%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

ADDITIVE PACKAGE

Fraction By Weight: <10%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- LUBRICATING OILS ARE GENERALLY CONSIDERED NO
MORE THAN MINIMALLY IRRITATING TO EYES & SKIN. INHALATION OF VAPOR
(GENERATED AT HIGH TEMPERATURE S ONLY)/OIL MIST MAY CAUSE MILD
IRRITATION OF UPPER RESPIRATORY TRACT. SLIGHTLY TOXIC IF SWALLOWED.
CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:WARNING! USED MOTOR OILS WERE SHOWN TO
CAUSE SKIN CANCER WHEN REPEATEDLY APPLIED TO MICE WITHOUT CLEANING
SKIN.
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, ABDOMINAL PAIN,
TEARING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:REMOVE
CONTAMINATED CLOTHING. WIPE EXCESS OFF. WASH SKIN WITH SOAP &
WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FR ESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO
NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS
LARGE AMOUNTS OF PRODUCT ARE INGESTED. HOWEVER, GET MEDICAL ADVICE.

Flash Point Method:COC
Flash Point:310F,154C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINER MAY RUPTURE. COOL CONTAINERS
WITH WATER SPRAY.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. REMOVE SPILL WITH
INERT ABORBENT SUCH AS SAND, CLAY, EARTH. TRANSFER TO PROPER
CONTAINERS FOR DISPOSAL. PREVENT RUN-OFF TO ENTER SEWERS OR
WATERWAYS. FLUSH AREA WITH WATER T O REMOVE TRACE RESIDUE.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A DRY PLACE AWAY FROM OPEN
FLAMES AND STRONG OXIDIZING AGENTS. KEEP CONTAINER CLOSED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE. ALL PRECAUTIONS
SHOULD BE OBSERVED. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF
REACH OF CHILDREN. AVOID BREATHING MISTS/VAPORS. AVOID REPEATED
SKIN CONTACT. DO NOT GET IN EYES. DO NOT INGEST.

Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. IF
HIGH VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH APPROVED
CHEMICAL CARTRIDGE RESPIRATOR FOR ORGANIC VAPORS AND MISTS. REFER
TO 29 CFR 1910.134.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:NITRILE IF FREQUENT CONTACT EXPECTED
Eye Protection:SAFETY GOGGLES IF SPLASHING ANTICIPATED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DIFFERENT FORMULA. FOR OTHER FORMULATIONS, SEE PNI B, C OR D, SAME NSN.
NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS UNNECESSARY IN
HIGH VISCOSITY, LOW VOLATILITY PRODUCTS, I.E., MOST OILS AND G
REASES.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:-2F,-19C
Spec Gravity:0.8990
Viscosity:128 CS @ 39F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN LIQUID - SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAMES
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL STATE AND
FEDERAL LAWS. PRODUCT IS AN OIL. SPILLS TO US SURFACE
WATERS/WATERCOURSE/SEWER THAT CAUSE A VISIBLE SHEEN MUST BE
REPORTED TO NATIONAL RESPONSE CENTER 800 -424-8802. THIS IS NOT A
HAZARDOUS WASTE BY RCRA.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.